Video: Power Steering Pump Replacement On Discovery Series II
Watch Doug, our Land Rover Master Technician, show you how to access and replace the power steering pump on a 1999-2004 Discovery Series II . The power steering pump, which is part # QVB500080OE is a common replacement item, and it is recommended that the hoses related to this installation be replaced too. Power Steering Hose Kit # 9397D2 , includes the pump to box, reservoir to pump, and low pressure hoses. Doug also covers the power steering reservoir (QFX100371) discussing issues that develop over time with this item. You will also need the ACE and Power Steering Fluid. Doug shows the genuine fluid STC50519 in the video. There is also now an excellent aftermarket alternative for this fluid now from Rock Oil that we recommend (and will save you a few $$.)
Kit # QVB500080OE Installing Power Steering Pump & Hoses and Fluid on Discovery Series II, 1999-2004, 8-Cylinder Gasoline, North American SpecificationsHi I'm Doug and I'm your tech support representative for Atlantic British, and in this video we are going to touch base on another very common repair, mostly on the Discovery 2s, Discovery 1s, P38s, any of the 4.0 or 4.6 engines, is power steering pump. You'll find that over a period of time there's several reasons why these pumps can fail. You may develop a bad power steering leak which is a wearout of the seal. Could be bearing failure, or an actual internal failure of the impeller or the drive unit internally. All right, so this is the pump that's going to be used on your vehicle. And essentially what you have here is most of your hydraulic system which is the pump, this is the gravity feed line that would run from the reservoir down to the pump, from the pump to the cooler, from the cooler to the power steering box, and then from the box back up to the reservoir. Now what happens is these can fail internally, you could have a leaky seal, or you can have a bearing failure. If it's an internal or a bearing failure I would generally recommend not only do you replace the hoses, you're going to take a good look at them when you take the system apart, but inside the reservoir, and I don't know how well you're going to see it on the video, but straight down inside you actually have a filter built into these reservoirs. If you have a pump failure or a hose failure, and these hoses can wear internally, they're just strictly rubber hoses. That material will build up on that filter. And that's basically there to keep those contaminants from going through the system. Eventually that filter can get plugged up to the point where you won't get sufficient flow from the reservoir down to the pump and create a whining, or an erratic steering. So if you've got 100,000 miles on it and you're replacing the pump due to a failure, or you've had a hose collapse internally, you want to get that reservoir as well. Make sure you have a good clean filter in there and it will help the system operate. And also importantly is the fluid that's used in the system. This is fluid supplied and made by Land Rover called Active Corner Enhancement Power Steering Fluid, or short ACE Fluid. And what will happen is if you use regular power steering fluid or Dexron 3 in these pumps, over a period of time it will cause internal damage. They're not made to be used with that fluid. This is the fluid that is specially formulated for the system, that can make a world of difference on how long it last you after you do a replacement. So what we're going to do now is going to show you how access and replace the pump, how to access the hoses and then do some visual inspections to give you an idea if you should be replacing other components as well. You'll see some bubbling in the top fluid, because we know we definitely pushed some air through there. Now we're just going to let it sit for about 15 or 20 minutes, let that air bleed out of the system, And then you can cap it off. And you should be ready to go. What I suggest is take it for a test drive. When you get home shut it off. Let it sit for a few minutes. And then double check your height. You may use a little bit more fluid. You may need to add just a little bit to get it to the full line. As of that, you've replaced your power steering pump, saved yourself a lot of money and ready to go for another 100,000 miles. So, when you're ready to change over your power steering pump or any of your hoses, just call any of our knowledgeable salesman at 1-800-533-2210. Thanks for watching.
Applies To These Models:Discovery Series II | 99 - 04LR3 / Discovery 3 V8 4.4L | 05 - 09LR3 / Discovery 3 V6 4.0L | 05 - 09LR4 / Discovery 4 V8 5.0 Liter | 10 - 13LR4 / Discovery 4 V6 3.0 Liter | 14 - 16Range Rover Full Size 4.4 (BMW Engine) | 03 - 05Range Rover Full Size 4.4 (Jag Engine) | 06 - 09Range Rover Full Size 4.2 Supercharged (Jag Engine) | 06 - 09Range Rover Full Size | 10 - 12Range Rover Full Size Supercharged | 10 - 12Range Rover Full Size V8 5.0L Naturally-Aspirated | 13Range Rover Full Size V8 5.0L Supercharged | 13 - OnRange Rover Full Size V6 3.0L Supercharged | 14 - OnRange Rover Sport | 06 - 09Range Rover Sport Supercharged | 06 - 09Range Rover Sport | 10 - 13Range Rover Sport Supercharged | 10 - 13Range Rover Sport V8 5.0L Supercharged | 14 - OnRange Rover Sport V6 3.0L Supercharged | 14 - OnRange Rover Sport V6 3.0L TDI | 14 - On
This video has been viewed: 149,521 times
Select a Category
1) Select Year
2024 2023 2022 2021 2020 2019 2018 2017 2016 2015 2014 2013 2012 2011 2010 2009 2008 2007 2006 2005 2004 2003 2002 2001 2000 1999 1998 1997 1996 1995 1994 1993 1992 1991 1990 1989 1988 1987 1986 1985 1984 1983 1982 1981 1980 1979 1978 1977 1976 1975 1974 1973 1972 1971 1970 1969 1968 1967 1966 1965 1964 1963 1962 1961 1960 1959 1958 1957 1956 1955 1954 1953 1952 1951 1950 1949 1948
2) Select Model
Customer service is phenomenal. My sales rep is a pleasure to work with and a real professional…
David K.Kittery, ME
5-6-24
Wide range of parts, excellent and professional customer service quick shipping.
Gregory R.MOJAVE, CA
5-3-24
Great product selection, great customer service!
Jose V.El Paso, TX
4-30-24
Every time I have ordered parts for my 2008 Range Rover Sport, my sales rep has been so helpful and gets my order sent out quickly.
Anita B.Newport News, VA
4-29-24
A wide variety of LR parts, very responsive and congenial customer service, and fast turn around from order to shipping.
James C.APO, AP, CA
4-28-24
You’re my go to for D2 parts and the repair videos
Adam P.GARDNER, KS
4-28-24
Professional customer service and excellent delivery on orders.
JEFFREY F.GROVETOWN, GA
4-27-24
Great service and great parts
Jay M.Verona, VA
4-22-24
You guys have great customer service and have always been able to get me the parts I need.
Derrick C.Dallas, TX
4-17-24
Professional and knowledgeable sales representatives, quick shipping, reasonable selection, and competitive pricing.
Michael S.Mesa, AZ
4-17-24
Shop by Vehicle
Shop by Category
Reviews from our Customers...
Previous Slide ◀︎
Next Slide ▶︎
FAST Shipping! Call these Folks they have all the answers to your part installation.
-Bill M. (Boydton,VA)
Great customer service, very knowledgeable staff. Everyone I have worked with are Land Rover owners- which is a big help for knowing the vehicles.
You always have the parts I need at a great price and everyone Ive ever spoken to has a great knowledge of all Land Rovers
-Keith B. (Blue Ridge,VA)
Professionalism. My sales rep is a rock star, and I value both his technical expertise and his knowledge of your product line.
-Alan R. (N. Chelmsford,MA)
FAST Shipping! Call these Folks they have all the answers to your part installation.
-Bill M. (Boydton,VA)
Great customer service, very knowledgeable staff. Everyone I have worked with are Land Rover owners- which is a big help for knowing the vehicles.
You always have the parts I need at a great price and everyone Ive ever spoken to has a great knowledge of all Land Rovers
-Keith B. (Blue Ridge,VA)
Professionalism. My sales rep is a rock star, and I value both his technical expertise and his knowledge of your product line.
-Alan R. (N. Chelmsford,MA)
You always have the parts I need at a great price and everyone Ive ever spoken to has a great knowledge of all Land Rovers
-Keith B. (Blue Ridge,VA)
Professionalism. My sales rep is a rock star, and I value both his technical expertise and his knowledge of your product line.
-Alan R. (N. Chelmsford,MA)
First slide details. Current Slide
Second slide details.
Third slide details.
Fourth slide details.